reaming in drill press
how much reaming alliance would you leave on a 1/2 in hole
1/8 times
what is the difference between a checking and a rose reamer
a checking reamer is a finished reamer, the fluted part is cylindrical and the land are relieved. a rose reamer is a roughing reamer. it can remove a considerable amount of material the body has a slight back taper and no relief on the lands. all cutting takes place on the chamfered end
what is a jobber's reamer
a jobber's reamer is a finishing reamer like a chucking reamer but has a longer fluted body
how does the surface finish of a hole affect its accuracy
an accurate hole size cannot be obtained without a high quality surface finish
how does the cutting speeds compare for drilling and reaming the same material
as a general rule the cutting speed used to ream a hole is about one third to half of the speed used to drill a hole of the same size in the same material
what causes a bellmouthed hole
bell mouthed hole are usually caused by misaligned reamer and workpiece set up. piloted reamers, bushing, or a floating holder may correct this problem
when are carbide tipped reamer used
carbide tipped reamers are recommended for long producing run where high abrasive material are reamed
why is vibration harmful to carbide tipped reamer
cemented carbide are hard but also brittle. the slightest amount of chatter or vibration may chip the cutting edges.
what can be done to overcome chatter
chatter may be eliminated by reducing the speed, increasing the feed or using a piloted reamer
what is the purpose of using cutting fluid while reaming
cutting fluid cool the tool and workpiece and act as a lubricate
how is a machine reamer identified verse a hand reamer
machine reamers are identified by the design of the shank either a straight or tapered shank and usually a 45 degreee chamfer on the cutting end
what will cause oversized hole
oversized holes may be caused by a bent reamer shank or buildup on the cutting edges, check also to see if there is a sufficient amount of coolant and if the correct kind is being used
why are shell reamers used
shell reamer are more economical to produce than solid reamer especially in larger size
how can loot surface finish be overcome
surface finish can be improved by decreasing the feed and checking the reaming alliance too much or not enough material will cause poor finish. use a large volume of coolant
how do the feed rates compare between drilling and reaming
the feed rate, when reaming as compared with drilling the same material, is approximately two to three times as great.