Section 11 Vehicle Inspection Test (11.1 Engine Compartment - Engine off)

Oil Level

Check oil level when engine is off. Indicate where dipstick is located. Check that the oil level is within safe operating range. Level must be above refill mark.

Engine Compartment Belts

Check the following belts for snugness (up to 3/4 inch play at center of belt), cracks, or frays: -Power steering belt. -Water pump belt. -Alternator belt. -Air compressor belt. -Make sure component(s) are operating properly, are not damaged or leaking, and are mounted securely.

Power Steering Fluid

Checks the dipstick and sees where the fluid level is relative to the refill mark or checks sight glass. Level must be above refill mark.

Vehicle Inspection Expectations

During the Vehicle inspection, you must show that the vehicle is safe to drive. You will have to walk around the vehicle, name and point to/ touch each item and explain to the examiner what you are checking and why. Any vehicle that has components marked or labeled cannot be used for the Vehicle Inspection test.

Note

If any of the components listed above are not belt driven, you must: Tell the examiner which component(s) are not belt driven. Make sure component(s) are operating properly, are not damaged or leaking, and are mounted securely

Leaks/Hoses

Look for puddles on the ground. Look for dripping fluids on underside of engine and transmission. Inspect hoses for condition and leaks.

Coolant Level

Looks at sight glass on radiator or coolant reservoir; adequate level will show in sight glass. If no sight glass is available, you must describe what s/he would look for after removing radiator cap.

Safe Start

Place gearshift lever in neutral (or park, for automatic transmissions). Depress clutch before attempting to start the vehicle Start the vehicle and keep clutch depressed until engine reaches idling speed. Then release clutch slowly.